考虑应力敏感性的低渗透油藏油井产能分析

doi:10.11743/ogg20130117

摘要/Abstract

摘要：

低渗透油藏的单井产能主要受储层应力敏感性的影响。油藏流体采出后,地层压力下降,有效应力增加,孔隙度和渗透率均降低,导致油井产能下降。笔者在只考虑基于渗透率降低对低渗透油井产能方程影响的基础上,考虑了孔隙度随应力变化对油井产能的影响,建立了同时考虑渗透率和孔隙度的产能应力敏感性方程,并提出了产能-应力敏感性指数的概念。随着低渗透储层应力敏感性的增强,应力敏感性常数增大,产能-应力敏感性指数同时增大,油井的日产油量迅速降低。新的产能-应力敏感性方程使低渗透油藏油井产能计算结果更加简化和准确。通过实例验证与分析,产能-应力敏感性指数对低渗透油藏单井产能有较强的影响,随着产能应力敏感性指数的增加,油井的无阻流量下降速度降低。与只考虑渗透率降低的油井产能方程相比,新方程更能反映低渗透油藏的实际生产情况,对合理开发低渗透油藏具有一定的指导意义。

关键词: 应力敏感性, 产能, 孔隙度, 渗透率, 低渗透油藏

Abstract:

Stress-sensitivity is one of the main factors that affect single well productivity in low-permeability rese-rvoirs.It is common sense that wells tend to produce less after certain volumes of reservoir fluids were recovered as that would cause drop-down in formation pressure,porosity and permeability and increase of effective stress.The authors modified the previous productivity function of low-permeability oil wells that only considers the influences of permeability decrease by incorporating the influences of stress on porosity,established a new stress-sensitive productivity function with both porosity and permeability being taken into consideration,and proposed the concept of productivity-stress-sensitivity index.Along with the intensifying of stress-sensitivity of low-permeability reservoirs and increase of stress-sensitivity constant,the productivity-stress-sensitivity index also enlarges,and daily oil production quickly shrinks.The new function simplifies the calculation process and improves the accuracy.Practices show that the productivity-stress-sensitivity index exerts a strong influence upon the productivity of wells in low-permeability reservoirs.As the index increases,the decreasing of open flow capacity of oil wells slows down.Compared with the old function,the new one reflects better the actual production of low-permeability reservoirs and therefore could be used to guide their development.

Key words: stress sensitivity, productivity, porosity, permeability, low-permeability reservoir

中图分类号:

TE312

刘峰,王裕亮,陈小凡,等. 考虑应力敏感性的低渗透油藏油井产能分析[J]. 石油与天然气地质, 2013, 34(1): 124-128. doi: 10.11743/ogg20130117 Liu Feng,Wang Yuliang,Chen Xiaofan,et al. Analysis on oil well productivity of low-permeability reservoirs with stress-sensitivity being taken into considerations[J]. Oil & Gas Geology, 2013, 34(1): 124-128. doi: 10.11743/ogg20130117

参考文献

[1] 王厉强,刘慧卿,甄思广.低渗透储层应力敏感性定量解释研究[J].石油学报,2009,30(1):96-99. Wang Liqiang,Liu Huiqing,Zhen Siguang.Quantitative research on stress sensitivity of low-permeability reservoir[J].Acta Petrolei Sinica,2009,30(1):96-99.
[2] 郑荣臣,王昔彬,刘传喜.致密低渗气藏储集层应力敏感性试验[J].新疆石油地质,2006,27(3):345-347. Zheng Rongchen,Wang Xibin,Liu Chuanxi.The stress sensitivity test for dense reservoir rocks in low permeability gas pool[J].Xinjiang Petroleum Geology,2006,27(3):345-347.
[3] 刘仁静,刘慧卿,张红.低渗透储层应力敏感性及其对石油开发的影响[J].岩石力学与工程学报,2011,30(1):2697-2702. Liu Renjing,Liu Huiqing,Zhang Hongling.Study of stress sensitivity and its influence on oil development in low permeability reservoir[J].Chinese Journal of Rock Mechanics and Engineering,2011,30(1):2697-2702.
[4] Iscanag,Kokmv,Bagcas.Estimation of permeability and rock mechanical properties of limestone reservoir rocks under stress conditions by strain gauge[J].Journal of Petroleum Science and Engineering,2006,53(1):13-4.
[5] Mckeecr,Bumbac,Koenigra.Stress dependent permeability and porosity of coal and other geologic formations[J].SPE Formation Evaluation,1988,3(1):81-91.
[6] Farquhar R A,Smart B G D,Todd A C,et al.Stress sensitivity of low-permeability sandstones from the rotliegendes sandstone[J].SPE,26501.
[7] 高博禹,周涌沂,彭仕宓.储层孔隙度应力敏感性研究[J].石油实验地质,2005,27(2):197-201. Gao Boyu,Zhou Yongyi,PengShimi.Study on the stress sensibility of reservoir porosity[J].Petroleum Geology & Experiment,2005,27(2):197-201.
[8] 于忠良,熊伟,高树生,等.致密储层应力敏感性及其对油田开发的影响[J].石油学报,2007,28(4):95-98. Yu Zhongliang,Xiong Wei,Gao Shusheng.Stress sensitivity of tight reservoir and its influence on oilfield development[J].Acta Petrolei Sinica,2007,28(4):95-98.
[9] 刘启国,唐伏平,冯国庆,等.开关井不同程度应力敏感效应对井底压力动态的影响[J].石油与天然气地质,2007,28(4):523-527. Liu Qiguo,Tang Fuping,FengGuoqing.Influence of different stress sensitivities on bottom hole pressure behaviors during well opening and shut-in[J].Oil & Gas geology,2007,(4):523-527.
[10] 郭肖,伍勇.启动压力梯度和应力敏感效应对低渗透气藏水平井产能的影响[J].石油与天然气地质,2007,28(4):539-543. GuoXiao,Wu Yong.Influence of start-up pressure gradient and stress sensitivity on productivity of low-permeability gas reservoirs[J].Oil & Gas geology,2007,28(4):539-543.
[11] 刘建军,刘先贵.有效压力对低渗透多孔介质孔隙度、渗透率的影响[J].地质力学学报,2001,7(1):41-44. Liu Jianjun,Liu Xiangui.The effect of effective pressure on porosity and permeability of low permeability porous media[J].Journal of Geomechanics,2001,7(1):41-44.
[12] 严谨,刘传喜.高含CO₂气井产能计算新方法[J].石油与天然气地质,2011,32(54):787-791. Yan Jin,Liu Chuanxi.A new method of productivity prediction for high CO₂-content gas wells[J].Oil & Gas geology,2011,32(54):787-791.
[13] 廖纪佳,唐洪明,朱筱敏,等.特低渗透砂岩储层水敏实验及损害机理研究——以鄂尔多斯盆地西峰油田延长组第8油层为例[J].石油与天然气地质,2012,33(2):321-327. Liao Jijia,Tang Hongming,Zhu Xiaomin.Water sensitivity experiment and damage mechanism of sandstone reservoirs with ultra-low permeability:a case study of the eighth oil layer in the Yanchang Formation of Xifeng oilfield,Ordos Basin [J].Oil & Gas geology,2012,3(2):321-327.
[14] 阮敏,王连刚.低渗透油田开发与压敏效应[J].石油学报,2002,23(2):73-76. Ruan Min,Wang Liangang.Low-permeability oilfield development and pressure-sensitive effect[J].Acta Petrolei Sinica,2002,23(2):73-76.
[15] 刘双莲,李浩,周小鹰.大牛地气田大12-大66井区沉积微相与储层产能关系[J].石油与天然气地质,2012,33(2):45-49. Liu Shuanglian,Li Hao,Zhou Xiaoyin.Relationship between sedimentary microfacies and reservoir productivity in Da12-Da66 wellblock,Daniudi gas field[J].Oil & Gas geology,2012,33(2):45-49.
[16] 吴凡,孙黎娟,何江.孔隙度、渗透率与净覆压的规律研究和应用[J].西南石油学院学报,1999,21(4):23-25. Wu Fan,Sun Lijuan,He Jiang.The research and application of permeability,porosity and net overburden pressure laws[J].Journal Of Southwest Ptroleum Institute,1999,21(4):23-25.
[17] 李传亮.应力敏感对油井产能的影响[J].西南石油大学学报,2009,31(1):170-172. Li Chuanliang.Stress sensitivity influence on oil well producti-vity[J].Journal of Southwest Petroleum University,2009,31(1):170-172.
[18] 王秀娟,赵永胜,文武,等.低渗透储层应力敏感性与产能物性下限[J].石油与天然气地质,2003,24(2):162-166. Wang Xiujuan,Zhao Yongsheng,Wen Wu et al.Stress sensitivity and poroperm lower limit of deliverability in the low-permeability reservoir[J].Oil & Gas geology,2003,24(2):162-166.
[19] 李传亮,杨学锋.低渗透储集层油藏的产能特征分析[J].新疆石油地质,2006,27(5):566-5681. Li Chuanliang,Yang Xuefeng.Productivity behavior of low permeability reservoirs[J].Xinjiang Petroleum Geology,2006,27(5):566-5681.
[20] 王恒贵.应力敏感储层油井产能损失计算模型[J].油气田地面工程,2010,29(10):40-41. Wang Henggui.Stress sensitivity of reservoir oil well productivity of loss calculation model[J].Oil and Gas Field Surface Engineering,2010,29(10):40-41.
[21] 尹琅,黄全华,张茂林.考虑应力敏感的气井产能分析[J].西南石油大学学报,2009,29(11):46-49. Yin Lang,Huang Quanhua,Zhang Maolin.Stress sensitive effect on gas well productivity[J].Journal of Southwest Petro-leum University,2009,29(11):46-49.
[22] 李传亮.储层岩石的应力敏感性评价方法[J].大庆石油地质与开发,2006,25(1):40-42. Li Chuanliang.Evaluation method for stress sensitivity of reservoir rock[J].Petroleum Geology & Oil Field Development in Daqing,2006,25(1):40-42.
[23] 李传亮.油藏工程[M].北京:石油工业出版社,2005:89-91. Li Chuanliang.Reservoir engineering [M] Beijing:Petroleum Industry Press,2005:89-91.
[24] 吴小庆.数学物理方程及其应用[M].北京:石油工业出版社,2008:253-258. Wu Xiaoqing.Equations of mathematical physics and its application[M].Beijing:Petroleum Industry Press,2008:253-258.