四川盆地川西坳陷新场气田须家河组储层工程地质特征及增产实践

doi:10.11743/ogg20210420

摘要/Abstract

摘要：

储层增产技术是川西深层致密砂岩气藏开发的关键技术。川西坳陷新场气田须家河组二段为典型的深层致密砂岩气藏，具有储层致密、最小主应力与垂向应力接近的走滑断层应力状态以及储层裂缝发育等特点，前期储层改造效果不明显。针对须家河组储层开展了工程地质特征评价和前期压裂效果分析，在储层岩相、岩石学、物性和裂缝等特征研究基础上，将储层分为3大类地质工程双甜点类型。其中断缝体型甜点可通过氮气钻井、小规模试破和酸化建产，层理缝型甜点可通过近井深度解堵及复合改造工艺建产，孔隙型甜点需要通过超高压大规模体积压裂工艺实现建产。X8-2井主要钻遇断缝体型储层，通过氮气钻井测试获得稳定无阻流量达53×10⁴ m³/d，而钻遇孔隙型甜点储层的XS101井可通过大规模体积压裂获得稳定产量（15×10⁴ m³/d）。这些井的实践成功为川西坳陷须家河组天然气资源的有效动用提供了经济可行的增产技术对策。

关键词: 储层改造, 氮气钻井, 储层增产, 气藏开发, 致密砂岩气藏, 须家河组, 新场气田, 川西坳陷

Abstract:

Reservoir stimulation is a key technology to develop the tight gas reservoir in the Western Sichuan Basin.The second member of the Xujiahe Formation (hereinafter referred to as Tx²), a typical deep tight formation, is characterized by tightness, strike-slip fault stress state with minor principal stress close to vertical stress, and well-developed fractures within, and the effect of reservoir simulation is quite limited at the early stages.The engineering geological evaluation and analysis of the previous hydraulic fracturing operation in the Xujiahe Formation are carried out, and three types of "double sweet spots" (namely, the sweet spot both geologically and geomechanically) are determined based on lithofacies, petrology, physical properties and natural fractures.Among others, the fault-fracture type could be developed by nitrogen drilling, small-scale fracturing and acidizing; the bedding-parallel fracture type could be developed by the near-wellbore deep plugging removing and integrated stimulation technique; and the pore type needs to be fractured by volume fracturing under ultra-high pressure.In practice, Well X8-2 encountering fault-fracture type sweet spot achieves a steady open flow rate of 53×10⁴ m³/d through nitrogen drilling, and Well XS101 encountering pore type sweet spots achieves a steady production rate of 15×10⁴ m³/d through large-scale volume fracturing.The success of Wells X8-2 and SX101 shows that these technologies are effective in stimulation of the tight gas reservoirs, thus being applicable for the effective development of natural gas resources in the Xujiahe Formation, Western Sichuan Depression.

Key words: reservoir stimulation, nitrogen drilling, reservoir stimulation, gas reservoir development, tight sandstone reservoir, Xujiahe Formation, Xinchang gas field, Western Sichuan Depression

中图分类号:

TE357

朱化蜀,刘林,黄志文,等. 四川盆地川西坳陷新场气田须家河组储层工程地质特征及增产实践[J]. 石油与天然气地质, 2021, 42(4): 1002-1010. doi: 10.11743/ogg20210420 Huashu Zhu,Lin Liu,Zhiwen Huang,et al. Reservoir engineering geological characteristics and stimulation in Xujiahe Formation, Xinchang gas field, Western Sichuan Depression, Sichuan Basin[J]. Oil & Gas Geology, 2021, 42(4): 1002-1010. doi: 10.11743/ogg20210420

图/表 10

图1

图2

图3

图4

图5

图6

图7

图8

图9

图10

参考文献 20

1	杨克明, 朱宏权. 川西叠覆型致密砂岩气区地质特征[J]. 石油实验地质, 2013, 35 (1): 1- 8.
	Yang Keming , Zhu Hongquan . Geological characteristics of superposed tight sandstone gas-bearing areas in western Sichuan[J]. Petroleum Geology & Experiment, 2013, 35 (1): 1- 8.
2	金文正, 汤良杰, 杨克明, 等. 龙门山冲断带构造特征研究主要进展及存在问题探讨[J]. 地质论评, 2008, 54 (1): 37- 46.
	Jin Wenzheng , Tang Liangjie , Yang Keming , et al. Progress and problem of study on characters of the Longmen mountain Thrust Belt[J]. Geological Review, 2005, 54 (1): 37- 46.
3	郭新江, 蒋祖军, 胡永章. 天然气井工程地质[M]. 北京: 中国石化出版社, 2012: 325- 343.
	Guo XInjiang , Jiang Zujun , Hu Yongzhang . Engineering geoiogy of gas well[M]. Beijing: China Petrochemical Press, 2012: 325- 343.
4	欧彪, 梁大川, 孙勇, 等. 川西须家河组气藏水平井钻、完井液技术[J]. 广东化工, 2015, 42 (12): 47- 48. doi: 10.3969/j.issn.1007-1865.2015.12.022
	Ou Biao , Liang Dachuan , Sun Yong , et al. Study of horizontal well drill in fluid in West-Sichuan xujiahe gas reservoir[J]. Guangdong Chemical Industry, 2015, 42 (12): 47- 48. doi: 10.3969/j.issn.1007-1865.2015.12.022
5	刘斌, 方行, 颜晋川, 等. 低渗致密气藏压裂过程中伤害实验研究[J]. 断块油气田, 2009, 16 (1): 81- 82.
	Liu Bin , Fang Xing , Yan Jinchuan , et al. Experimental study on fracturing damage in lowpermeability tight gas reservoir[J]. Fault-Block Oil & Gas Field, 2009, 16 (1): 81- 82.
6	郭彤楼. 四川盆地北部陆相大气田形成与高产主控因素[J]. 石油勘探与开发, 2013, 40 (2): 139- 149.
	Guo Tonglou . Key controls on accumulation and high production of large non-marine gas fields in northern Sichuan Basin[J]. Petroleum Exploration and Development, 2013, 40 (2): 139- 149.
7	吕文雅, 苗凤彬, 张本键, 等. 四川盆地剑阁地区须家河组致密砾岩储层裂缝特征及对天然气产能的影响[J]. 石油与天然气地质, 2020, 41 (3): 484- 491.
	Lyu Wenya , Miao Fengbin , Zhang Benjian , et al. Fracture characteristics and their influence on natural gas production: A case study of the tight conglomerate reservoir in the Upper Triassic Xujiahe Formation in Jiange area, Sichuan Basin[J]. Oil & Gas Geology, 2020, 41 (3): 484- 491.
8	张世华, 田军, 叶素娟, 等. 川西坳陷新场构造带须二段气藏成藏过程[J]. 天然气工业, 2019, 39 (1): 17- 22.
	Zhang Shihua , Tian Jun , Ye Sujuan , et al. Reservoir formation process of the second Member of Upper Triassic Xujiahe Fm in the Xinchang structural zone of the Western Sichuan Depression[J]. Natural Gas Industry, 2019, 39 (1): 17- 22.
9	叶泰然, 刘殊, 张虹. 川西坳陷东西向弧形构造带与基底断坡的关系[J]. 成都理工大学学报(自然科学版), 2018, 45 (3): 257- 267. doi: 10.3969/j.issn.1671-9727.2018.03.01
	Ye Tairan , Liu Shu , Zhang Hong . Relationship between the basement uplift and the arc structure in the Western Sichuan Depression[J]. Journal of Chengdu University of Technology(Science & Technology Edition), 2018, 45 (3): 257- 267. doi: 10.3969/j.issn.1671-9727.2018.03.01
10	Zhang Jincai , Zheng Herong , Wang Guoli , et al. In-situ stresses, abnormal pore pressures and their impacts on the Triassic Xujiahe gas reservoirs in tectonically active western Sichuan basin[J]. Marine & Petroleum Geology, 2020, 122, 1- 16.
11	唐大海, 谭秀成, 王小娟, 等. 四川盆地须家河组致密气藏成藏要素及有利区带评价[J]. 特种油气藏, 2020, 27 (3): 40- 46. doi: 10.3969/j.issn.1006-6535.2020.03.007
	Tang Dahai , Tan Xiucheng , Wang Xiaojuan , et al. Tight gas accumulation elements and favorable zone evaluation of Xujiahe Formation in Sichuan Basin[J]. Specail Oil & Gas Reservoirs, 2020, 27 (3): 40- 46. doi: 10.3969/j.issn.1006-6535.2020.03.007
12	牛小兵, 冯胜斌, 尤源, 等. 致密储层体积压裂作用范围及裂缝分布模式-基于压裂后实际取心资料[J]. 石油与天然气地质, 2019, 40 (3): 669- 677.
	Niu Xiaobing , Feng Shengbin , You Yuan , et al. Fracture extension and distribution pattern of volume fracturing in tight reservoir: An analysis based on actual coring data after fracturing[J]. Oil & Gas Geology, 2019, 40 (3): 669- 677.
13	邱登峰, 云金表, 刘全有, 等. 不同边界条件断层端部应力集中效应及对裂缝发育的启示[J]. 石油与天然气地质, 2019, 40 (1): 205- 214.
	Qiu Dengfeng , Yun Jinbiao , Liu Quanyou , et al. The stress concentration effect at fault end under various boundary conditions and its implications for fracture development[J]. Oil & Gas Geology, 2019, 40 (1): 205- 214.
14	钟森, 王兴文, 慈建发. 致密砂岩气藏提高返排效果技术对策[J]. 天然气技术与经济, 2016, 10 (5): 28- 31. doi: 10.3969/j.issn.2095-1132.2016.05.007
	Zhong Sen , Wang Xingwen , Ci Jianfa . Countermeasures against improving flowback efficiency for tight sandstone gas reservoirs[J]. Natural Gas Technology, 2016, 10 (5): 28- 31. doi: 10.3969/j.issn.2095-1132.2016.05.007
15	黄禹忠, 任山, 林永茂, 等. 川西马井气田蓬莱镇组气藏储层改造技术研究应用[J]. 钻采工艺, 2007, 30 (1): 35- 37. doi: 10.3969/j.issn.1006-768X.2007.01.012
	Huang Yuzhong , Ren Shan , Lin Yongmao , et al. Applied research on stimulation technology in penglaizhen formation in majing gas field of west sichuan[J]. Drilling & Production Technology, 2007, 30 (1): 35- 37. doi: 10.3969/j.issn.1006-768X.2007.01.012
16	刘忠群, 徐士林, 刘君龙, 等. 四川盆地川西坳陷深层致密砂岩气藏富集规律[J]. 天然气工业, 2020, 40 (2): 31- 40.
	Liu Zhongqun , Xu Shilin , Liu Junlong , et al. Enrichment laws of deep tight sandstone gas reservoirs in the Western Sichuan Depression, Sichuan Basin[J]. Natural Gas Industry, 2020, 40 (2): 31- 40.
17	孙焕泉, 周德华, 赵培荣, 等. 中国石化地质工程一体化发展方向[J]. 油气藏评价与开发, 2021, 11 (3): 269- 280.
	Sun Huanquan , Zhou Dehua , Zhao Peirong , et al. Geology-engineering integration development direction of Sinopec[J]. Reservoir Evaluation and Development, 2021, 11 (3): 269- 280.
18	胡东风, 王良军, 黄仁春, 等. 四川盆地中国石化探区油气勘探历程与启示[J]. 新疆石油地质, 2021, 42 (3): 283- 290.
	Hu Dongfeng , Wang Liangjun , Huang Renchun , et al. Petroleum exploration history and enlightenment in Sichuan Basin: A case study on Sinopec exploration areas[J]. Xinjiang Petroleum Geology, 2021, 42 (3): 283- 290.
19	康保平, 黄小燕, 郭淑萍, 等. 川西坳陷须二气藏气田水成因、运移及其成藏演化[J]. 石油与天然气地质, 2018, 39 (2): 309- 317.
	Kang Baoping , Huang Xiaoyan , Guo Shuping , et al. Origin, migration, and accumulation evolution of reservoir water in the gas field with Xu 2 gas reservoir, western Sichuan Depression, Sichuan Basin[J]. Oil & Gas Geology, 2018, 39 (2): 309- 317.
20	龙刚, 朱化蜀, 王希勇, 等. 川西低渗气藏气体钻井提速潜力评价[J]. 钻采工艺, 2011, 34 (4): 25- 27.
	Long Gang , Zhu Huashu , Wang Xiyong , et al. Evaluation of gas drilling potrntial rop in Chuanxi low permeability gas reservoirs[J]. Drilling & Production Technology, 2011, 34 (4): 25- 27.

[1]	李双建, 李智, 张磊, 李英强, 孟宪武, 王海军. 四川盆地川西坳陷三叠系盐下超深层油气成藏条件与勘探方向[J]. 石油与天然气地质, 2023, 44(6): 1555-1567.
[2]	曾溅辉, 张亚雄, 张在振, 乔俊程, 王茂云, 陈冬霞, 姚泾利, 丁景辰, 熊亮, 刘亚洲, 赵伟波, 任克博. 致密砂岩气藏复杂气-水关系形成和分布主控因素及分布模式[J]. 石油与天然气地质, 2023, 44(5): 1067-1083.
[3]	袁静, 周涛, 乔俊, 杨贵丽, 赵广昊. 深层砂砾岩中的深部热流体作用及其地质意义[J]. 石油与天然气地质, 2022, 43(4): 929-942.
[4]	岳亮, 孟庆强, 刘自亮, 杨威, 金惠, 沈芳, 张军建, 刘四兵. 致密砂岩储层物性及非均质性特征[J]. 石油与天然气地质, 2022, 43(3): 597-609.
[5]	徐亮, 杨威, 姜振学, 陈冬霞, 王耀华, 鲁健康, 赵明珠, 李兰. 四川盆地川西坳陷三叠系须家河组页岩有机孔演化及成因[J]. 石油与天然气地质, 2022, 43(2): 325-340.
[6]	苏成鹏, 何莹, 宋晓波, 董波, 吴小奇. 四川盆地川西气田中三叠统雷口坡组气藏气源再认识[J]. 石油与天然气地质, 2022, 43(2): 341-352.
[7]	吴小奇, 陈迎宾, 翟常博, 周凌方, 周小进, 杨俊, 王彦青, 宋晓波. 川西坳陷中三叠统雷口坡组沥青地球化学特征及气源示踪[J]. 石油与天然气地质, 2022, 43(2): 407-418.
[8]	刘畅, 张道旻, 李超, 路媛媛, 于姗姗, 郭明强. 鄂尔多斯盆地临兴区块上古生界致密砂岩气藏成藏条件及主控因素[J]. 石油与天然气地质, 2021, 42(5): 1146-1158.
[9]	郑和荣, 刘忠群, 徐士林, 刘振峰, 刘君龙, 黄志文, 黄彦庆, 石志良, 武清钊, 范凌霄, 高金慧. 四川盆地中国石化探区须家河组致密砂岩气勘探开发进展与攻关方向[J]. 石油与天然气地质, 2021, 42(4): 765-783.
[10]	陈洪德, 刘磊, 林良彪, 王兴龙, 王志伟, 余瑜, 曾剑, 李朋威. 川西坳陷西部龙门山隆升时期上三叠统须家河组沉积响应[J]. 石油与天然气地质, 2021, 42(4): 801-815.
[11]	林良彪, 余瑜, 南红丽, 陈洪德, 刘磊, 吴冬, 王志康. 四川盆地川西坳陷上三叠统须家河组四段储层致密化过程及其与油气成藏的耦合关系[J]. 石油与天然气地质, 2021, 42(4): 816-828.
[12]	叶素娟, 杨映涛, 张玲. 四川盆地川西坳陷上三叠统须家河组三段和五段“甜点”储层特征及分布[J]. 石油与天然气地质, 2021, 42(4): 829-840, 862.
[13]	楼章华, 苏一哲, 朱蓉, 刘一锋, 徐士林, 李王鹏. 四川盆地新场构造带上三叠统须家河组二段地层水化学动态特征及其成因[J]. 石油与天然气地质, 2021, 42(4): 841-851.
[14]	刘君龙, 胡宗全, 刘忠群, 金武军, 肖开华, 毕有益, 李吉通. 四川盆地川西坳陷新场须家河组二段气藏甜点模式及形成机理[J]. 石油与天然气地质, 2021, 42(4): 852-862.
[15]	黄彦庆, 刘忠群, 林恬, 肖开华, 王爱, 薛明喜, 霍志周. 川东北元坝地区须家河组三段基于相控的相对优质储层预测[J]. 石油与天然气地质, 2021, 42(4): 863-872.